Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Clutch actuator arm pin removal
#1
On some gearboxes with a lever-operated clutch, the clutch actuator is held onto the pivot by a peculiar threaded pin that looks like the tail end of a bolt. Others report difficulties in getting this out, so I though I'd post a method which worked well for me.

First point is that this isn't a bolt and despite being threaded it doesn't unscrew. It's a smooth-sided interference fit pin, and has to be pulled out. Citroen dealers use a special tool which screws onto the threaded section. If you don't have this, a tool can be made from four M7, 1mm thread-pitch nuts. Ebay seller aboltfromtheblue can supply.

Take three of the nuts and drill them to 8mm so as to have a completely smooth bore. These will serve as spacers. Grease two and slide them onto the  pin, followed by a threaded M7 nut. Tighten the threaded nut until the grip of the pin breaks and it starts to pull out. If it is reluctant, tap the pin end with a small hammer while you turn, to help break the grip. Mine came quite easily. Wind the nut, pulling the pin out, until the thread goes stiff, which means your nut has reached the unthreaded section of the pin. Wind it back off and put the third smoothbore nut under it. Repeat, and the pin should now be loose enough to pull out.

To put back in, just protect the thread with a nut, and tap the narrowed end with a small hammer.
[-] The following 2 users say Thank You to IanR for this post:
  • brodfather11, ddb
Reply


Messages In This Thread
Clutch actuator arm pin removal - by IanR - 28-01-2015, 06:42 PM

Forum Jump:


Users browsing this thread: 1 Guest(s)
[-]
Welcome
You have to register before you can post on our site.

Username:
  

Password:
  




[-]
Search
(Advanced Search)

[-]
Latest Threads
Service interval notice
Last Post: jocas74
Today 02:23 AM
» Replies: 7
» Views: 358
Winter Tyres
Last Post: geoff
Today 12:19 AM
» Replies: 0
» Views: 16
23 plate Citreon Berlingo classed as a van
Last Post: W Petsa
Yesterday 10:39 PM
» Replies: 2
» Views: 34
The creation of my personal solo-travellor.
Last Post: EM58
Yesterday 06:17 PM
» Replies: 12
» Views: 740
M59 Throttle pedal
Last Post: evdama
Yesterday 01:10 PM
» Replies: 5
» Views: 178
Berlingo 2007 1.6 hdi - intermittent sticky acce...
Last Post: Romahomepete
Yesterday 01:05 PM
» Replies: 7
» Views: 329
roof rack with slats
Last Post: BigVtwin996
Yesterday 11:53 AM
» Replies: 4
» Views: 192
Battery upgrade
Last Post: evdama
27-03-2024 03:58 PM
» Replies: 0
» Views: 99
Wanted: 2003 M59 steering rack
Last Post: evdama
27-03-2024 12:45 PM
» Replies: 1
» Views: 57
Airbag Fault Code
Last Post: Cumbrian
26-03-2024 03:06 PM
» Replies: 1
» Views: 214

[-]
Recent Visitors
Locations of visitors to this page

[-]
Hosting by

QuickHostUK