Thread Rating:
  • 2 Vote(s) - 2 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] 1.6 HDI Blue Smoke From Engine Bay (Constaantly)
#1
Hey guys,

Just joined after reading this forum for the past few days and couldn't find anything about this anywhere.

Recently brought a 1.6hdi 2007 berlingo van and the very next day noticed a small amount of blue smoke coming from the engine bay. Tried to trace it back to it's source but haven't been able to yet.

Took it to my local garage yesterday to book it in for a full service and see if they could spot the problem and they reckon it is a "valve seal?".

Anyone here experienced this or know what I should be looking for?

Am just going through the manual i found on here to see if i can dismantle any of the other plastics off the engine so i can get a better look and gave the engine a quick clean earlier to remove a lot of the oil that's caked up all over the top of it but can't see anything suspect at the moment.

Thanks in advance
Lewis
Reply
#2
Get yourself a new garage!
It sounds like your injectors are leaking, exhaust fumes blowing past the seals and past the injector into the engine bay. This is likely if you have lots of oil around the top of the engine.
If this is the case then it is A BIG PROBLEM if not sorted and leads to the oil becoming contaminated which in turn leads to turbo failure.
New seals cost less than a fiver and should sort your problem.
[+] 1 user says Thank You to JohnM for this post
Reply
#3
As above sounds like injector seals.

However if you have heavy caking like it sounds like, then your going to have hell of a job pulling the injectors.

I would also recommend getting this problem sorted before you give it a service.
Reply
#4
Hello Lewi welcome to the forum as JohnM and homeruk wrote lift the engine cove off to see injector's start engine look at the injector's if there will be smoke coming past them and will be dirty black oily wet
                                     Smile  It's too orangey for crow's It's just for me and my dog  Smile

                                                        Heart Heart Love a lot trust a few  Dodgy
 
                                                        

                                        
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Reverse light switch prob...
Last Post:Col
Today 07:22 PM
» Replies: 12
» Views: 243
2004 Berlino Aerial
Last Post:Claydontoby92
Today 07:14 PM
» Replies: 0
» Views: 14
2005 2.0 HDI Siemens pump...
Last Post:Woodyrvf750
Today 07:05 PM
» Replies: 0
» Views: 15
Washers not working
Last Post:Silverberlingo
Today 06:54 PM
» Replies: 10
» Views: 268
Fuse is burning all the t...
Last Post:fernandoblas
Today 05:23 PM
» Replies: 12
» Views: 410
HELP! Smashed passenger w...
Last Post:Sootyfoot
Today 04:31 PM
» Replies: 2
» Views: 68
Diagnostic "gear" / Softw...
Last Post:cancunia
Today 04:19 PM
» Replies: 15
» Views: 612
Poor cold startup 1.9
Last Post:Top drive
Today 02:01 PM
» Replies: 38
» Views: 1031
Berlingo Parts
Last Post:malgpz900
Today 10:20 AM
» Replies: 1
» Views: 86
XTR heater control bulb r...
Last Post:Opensauce
Today 09:19 AM
» Replies: 1
» Views: 80

Locations of visitors to this page