Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Brake bleeding fault
#1
Thanks for letting me join. I have a 2007 Belingo Multispace 1.6 hdi
Hi, im having trouble with a 2007 Belingo Multispace 1.6 hdi concerning brake bleeding. I have replace both wheel cylinders and bled system. The pedal went away so i replaced the master cylinder. There is now a pedal but it has too much travel for my liking. If i let off and pump again then the pedal is good. I have carried out normal bleeding, pressure bleeding, clamp off the back and bleed fronts and vice versa. bled master cylinder bled ABS pump engine on and off. Adjusted rear brakes, cleaned front pads etc but still brake pedal travel...some help would be great...cheers
Reply
#2
Hello and welcome to the forum good to have you with us on the rear axle there is load sensor make sure it is open as if you were loaded get the berlingo jacked up as far as you can then bleed it see how you get on don't forget to release the load sensor after bleeding
                                     Smile  It's too orangey for crow's It's just for me and my dog  Smile

                                                        Heart Heart Love a lot trust a few  Dodgy
 
                                                        

                                        
Reply
#3
Uncle Jed has it right.Are you pressure bleeding?
Strawberry flavoured windows  Dodgy
Reply
#4
Get the front of the vehicle higher than the back the master cylinder reservoir tilts slightly forwards making them a pain to bleed.

And as others have said it helps if the load sensing valve is tied off open.
Reply
#5
How did you get on then?
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Running on chip oil
Last Post:polar
Today 04:07 AM
» Replies: 1
» Views: 12
Poor cold startup 1.9
Last Post:Top drive
Today 12:24 AM
» Replies: 40
» Views: 1081
2004 Berlino Aerial
Last Post:brodfather11
Yesterday 10:48 PM
» Replies: 1
» Views: 35
Washers not working
Last Post:Lighty
Yesterday 09:09 PM
» Replies: 11
» Views: 304
Reverse light switch prob...
Last Post:Col
Yesterday 07:22 PM
» Replies: 12
» Views: 263
2005 2.0 HDI Siemens pump...
Last Post:Woodyrvf750
Yesterday 07:05 PM
» Replies: 0
» Views: 32
Fuse is burning all the t...
Last Post:fernandoblas
Yesterday 05:23 PM
» Replies: 12
» Views: 417
HELP! Smashed passenger w...
Last Post:Sootyfoot
Yesterday 04:31 PM
» Replies: 2
» Views: 74
Diagnostic "gear" / Softw...
Last Post:cancunia
Yesterday 04:19 PM
» Replies: 15
» Views: 619
Berlingo Parts
Last Post:malgpz900
Yesterday 10:20 AM
» Replies: 1
» Views: 91

Locations of visitors to this page