Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Filters & Oil] Gear Box Oil, Where is it on the van?
#1
Hi, can anyone tell me where the gearbox oil is located on a 54 Plate Berlingo 1.9D Van, and how to top it up? And if possible which oil it is I need to purchase to top it up? Thanks Smile
Reply
#2
Hi,
On the 1.4 Multispace it's on the n/s of the gearbox - that's both the filler and drain plug, visible through the wheel arch.
Best check your hand book for your correcty oil.
HTH,
Griff
Landmark
Ex 1.4 Berlingo Multispace
[+] 1 user says Thank You to Landmark for this post
Reply
#3
Chris, I had a van the same as yours, but it was a long time ago! If memory serves me right the drain plug, was on the bottom of the gearbox, slightly angled towards the front of the van. I seem to remember using an ordinary spark plug spanner to remove it. The filler plug is accessed by removing the nearside front wheel, and is located on the rear edge of the end of the gearbox casing (at about the 4 o'clock position as you look at it). Fill with SAE 75/80 gear oil untill it starts to run out of the filler plug hole. Do NOT overtighten either filler/drain plug or you will strip the aluminium gearbox threads. I bought a £20 Ronseal pressure sprayer from B&Q which I have modified to make filling gearboxes easy. It has a long wand with a trigger on it for reaching into hard-to-reach filler holes.
[+] 1 user says Thank You to CourierJim for this post
Reply
#4
Filled my 2.0 HDi from above on Saturday after simply removing the breather and putting in the same amount that drained out when I pulled the driveshaft out - about a litre

Sent from cold, windy place.
2004 Multispace Desire HDi - "Bertie"
[+] 1 user says Thank You to mikep1973 for this post
Reply
#5
Smile 
Thanks for the help, i'll be hoping to get it done tonight
Reply
#6
As with any gearbox, make sure you can undo the filler plug before you attack the drain plug.
Mar 2002 Berlingo Multispace Forte 1.9D 166,000 miles
Reply
#7
(12-02-2015, 12:01 AM)GOOD CALL. Wrote:  As with any gearbox, make sure you can undo the filler plug before you attack the drain plug.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
increase in a ratchet-typ...
Last Post:saskak
Today 07:47 PM
» Replies: 5
» Views: 71
Rear hub nut torque setti...
Last Post:geoff
Today 07:31 PM
» Replies: 4
» Views: 75
Heyup
Last Post:polar
Today 07:18 PM
» Replies: 9
» Views: 365
New owner
Last Post:SheilaAnn
Today 04:33 PM
» Replies: 12
» Views: 569
Repair a manual winder wi...
Last Post:Col
Today 04:26 PM
» Replies: 3
» Views: 84
2-Button Key Upgrade
Last Post:Mojow Royle
Today 02:52 PM
» Replies: 1
» Views: 87
Poor cold startup 1.9
Last Post:Top drive
Today 02:46 PM
» Replies: 36
» Views: 878
peugeot charger
Last Post:Jed Clampit
Yesterday 11:28 PM
» Replies: 5
» Views: 179
hello
Last Post:Jed Clampit
Yesterday 11:16 PM
» Replies: 2
» Views: 60
XTR heater control bulb r...
Last Post:VicG
Yesterday 10:57 PM
» Replies: 0
» Views: 46

Locations of visitors to this page