Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Need help on where this hose and connector go to
#1
Hi guys, looking for some help here as im pretty clueless when it comes to mechanics.

I have a 2006 56 plate 1.9 diesel Berlingo which I've recently bought. The van idles at about 600 and runs rough for a couple of minutes from cold and then clears. I've had a quick look and noticed two things

1. Their is an air hose which is connected at one end and not the other as pictured below -

 [Image: $_86.JPG]

It comes from here -

[Image: $_86.JPG]

2. I have also noticed the plug pictured below is hanging free and not connected to anything and cant see anywhere for it to plug into.

[Image: $_86.JPG]

If anyone can point me in the right direction as to where the hose and connector are meant to go that would be great. Pulling my hair out looking here Angry
Reply
#2
Hi,It looks to me as though a previous owner has disabled the EGR valve.This is a common thing to do.Leave as is. Smile
Strawberry flavoured windows  Dodgy
[+] 2 users say Thank You to ron for this post
Reply
#3
Ok, so both the above air hose and connector relate to the egr valve ? This wouldnt cause the van to run rough when its first started from cold would it ?

Cheers
Reply
#4
I have seen no complaints of bad running.Make sure it's not only disconnected but blocked off as well.
Strawberry flavoured windows  Dodgy
Reply
#5
If you disconnect it on a Siemens HDi or a post 2004 Bosch HDi it'll complain a lot. Siemens will throw on the EML and go into limp mode, Bosch will run ok but put the EML on
2004 Multispace Desire HDi - "Bertie"
Reply
#6
(16-02-2015, 11:44 PM)mikep1973 Wrote:  If you disconnect it on a Siemens HDi or a post 2004 Bosch HDi it'll complain a lot. Siemens will throw on the EML and go into limp mode, Bosch will run ok but put the EML on
It's a 1.9 not HDi. Wink
Strawberry flavoured windows  Dodgy
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Washers not working
Last Post:CourierJim
Today 06:25 PM
» Replies: 9
» Views: 242
Reverse light switch prob...
Last Post:cancunia
Today 06:24 PM
» Replies: 11
» Views: 223
Fuse is burning all the t...
Last Post:fernandoblas
Today 05:23 PM
» Replies: 12
» Views: 399
HELP! Smashed passenger w...
Last Post:Sootyfoot
Today 04:31 PM
» Replies: 2
» Views: 56
Diagnostic "gear" / Softw...
Last Post:cancunia
Today 04:19 PM
» Replies: 15
» Views: 603
Poor cold startup 1.9
Last Post:Top drive
Today 02:01 PM
» Replies: 38
» Views: 1021
Berlingo Parts
Last Post:malgpz900
Today 10:20 AM
» Replies: 1
» Views: 79
XTR heater control bulb r...
Last Post:Opensauce
Today 09:19 AM
» Replies: 1
» Views: 80
Trip Computer on Type A M...
Last Post:cancunia
Today 09:18 AM
» Replies: 1
» Views: 63
DW8 engine tapping
Last Post:jj9
Today 01:14 AM
» Replies: 3
» Views: 124

Locations of visitors to this page