Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Berlingo 2 Heater Blower Problem
#1
I realise that this has been asked before, but I couldn't find the answer to the problem for a Berlingo poverty model without air-con. The problem is that the heater blower only works on full blast - number 4 setting. At the other three settings it is dead.

My van is a 2003 Berlingo 2 with no air-con. The part required is this one....

[Image: 20130129101145321.JPG]

They are around a tenner on eBay.

It is located above the heater blower. However, you don't need to remove the blower to get at it. If you open the glove compartment locker and shine a torch through the gap at the top you will see the plastic part of the unit to your right at the same level as the gap you are looking through. Reach under the trim below the glove box and unclip the plastic part. Then you can bring it out and unclip the wiring loom. No tools required! Re-fitting is a simple, reversal of this procedure.

I had a slight problem in that the white plastic moulding wasn't quite the same as the original and wouldn't just clip back in securely. Now, I reasoned that this resistor must be located where it is for a reason - to keep it cool and so I didn't re-locate it under the dash, but stuck it back in the right place using some glue.
[+] 1 user says Thank You to Nicepix for this post
Reply
#2
Hello Nicepix welcome to the forum good to have you with us Thank you for the wright up and photo perhaps some one for moderator team can move it to the howto section
                                     Smile  It's too orangey for crow's It's just for me and my dog  Smile

                                                        Heart Heart Love a lot trust a few  Dodgy
 
                                                        

                                        
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Washers not working
Last Post:Lighty
Today 09:09 PM
» Replies: 11
» Views: 291
Reverse light switch prob...
Last Post:Col
Today 07:22 PM
» Replies: 12
» Views: 248
2004 Berlino Aerial
Last Post:Claydontoby92
Today 07:14 PM
» Replies: 0
» Views: 21
2005 2.0 HDI Siemens pump...
Last Post:Woodyrvf750
Today 07:05 PM
» Replies: 0
» Views: 25
Fuse is burning all the t...
Last Post:fernandoblas
Today 05:23 PM
» Replies: 12
» Views: 415
HELP! Smashed passenger w...
Last Post:Sootyfoot
Today 04:31 PM
» Replies: 2
» Views: 69
Diagnostic "gear" / Softw...
Last Post:cancunia
Today 04:19 PM
» Replies: 15
» Views: 614
Poor cold startup 1.9
Last Post:Top drive
Today 02:01 PM
» Replies: 38
» Views: 1036
Berlingo Parts
Last Post:malgpz900
Today 10:20 AM
» Replies: 1
» Views: 89
XTR heater control bulb r...
Last Post:Opensauce
Today 09:19 AM
» Replies: 1
» Views: 84

Locations of visitors to this page