Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] 2.0hdi Starting issues
#1
Hi all some of us on this forum will know about the potential starting issues with the 2.0hdi engine and we know how important a good starter motor and battery are. I found these post on another forum and though they may be useful in giving people the heads up.


Many thanks given to Spider for this info, French Car Forum.


"The starting phase is entered as soon as the injection ECU is energised.
When starting, the injection ECU controls the following elements :
Booster pump (low pressure) (cuts out after 3 seconds, if the starter motor does not crank).
Preheater plugs (if necessary).
Fuel high pressure regulator (rise in pressure).

As soon as the starter motor is operated, the injection ECU sets the value of fuel high pressure from the coolant temperature.

At the beginning of starting, the high pressure regulator is controlled by the OCR worked out by the starting cartographic map.

In this operating phase, the high pressure fuel sensor is ignored.
The fuel high pressure is regulated by one of the parameters below :
Engine speed greater than 20 rpm with at least 4 revolutions completed.
Pressure in the high pressure fuel common injection rail greater than 150 bar.

The starting phase is finished when the engine speed exceeds a value." 

Also have a look atthis link 

http://frenchcarforum.co.uk/forum/viewto...11&t=43319
[+] 1 user says Thank You to polar for this post
Reply
#2
So the long and short of this is fit a new starter motor,.job done...
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
peugeot charger
Last Post:Jed Clampit
Yesterday 11:28 PM
» Replies: 5
» Views: 139
hello
Last Post:Jed Clampit
Yesterday 11:16 PM
» Replies: 2
» Views: 45
XTR heater control bulb r...
Last Post:VicG
Yesterday 10:57 PM
» Replies: 0
» Views: 18
Fuel consumption
Last Post:ron
Yesterday 09:41 PM
» Replies: 12
» Views: 277
Rear Wiper Motor
Last Post:minisandfords
Yesterday 08:48 PM
» Replies: 2
» Views: 82
Lower Ball Joint
Last Post:brodfather11
Yesterday 08:38 PM
» Replies: 2
» Views: 73
Bottom Ball joint
Last Post:Andyy
Yesterday 08:26 PM
» Replies: 6
» Views: 84
cutting out HDi 1.6 diese...
Last Post:Col
Yesterday 06:15 PM
» Replies: 18
» Views: 1438
Poor cold startup 1.9
Last Post:Top drive
Yesterday 06:10 PM
» Replies: 34
» Views: 810
starting problem
Last Post:brodfather11
Yesterday 03:32 PM
» Replies: 1
» Views: 45

Locations of visitors to this page