Thread Rating:
  • 25 Vote(s) - 2.56 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] 2.0 hdi turbo fault
#1
Hi guys

new to posting on the forum but have found it very helpful looking up all the little niggles on my 2003 2.0 hdi berlingo workhorse. I have what sounds like an air leak to, or from the turbo, when you go over 2000rpm it spools up ok and can hear it, but there is no boost. Had a look from under the van this morning, is it possible there could be a crack in the plastic pipe between turbo and inlet ? any advice please

thanks Chris
Reply
#2
It more likely that the boost pipe has just come loose. The boost pile is quite hard and unlikely to just crack. There only held on with a soft silicone joiner and a couple of crappy clamps. ( there 60 mm if you replace with jubilee clamp)
Reply
#3
(06-12-2011, 11:04 PM)duamoHDI Wrote:  It more likely that the boost pipe has just come loose. The boost pile is quite hard and unlikely to just crack. There only held on with a soft silicone joiner and a couple of crappy clamps. ( there 60 mm if you replace with jubilee clamp)

hi pal. my 1.6HDi berlingo makes a similar noise. has its just started to do this? mine has always had the noise from new. also im sure that on the 1.6 HDi the turbo is allways being used. its just works along side the engine from low to high Revs to assist the engine.
1.6 HDi Berlingo van , 2011 plate
Reply
#4
hi
thanks for your response, there is definateley a leak or valve stuck open somewhere. No fault lights on dash or black smoke from the exhaust, it just happened suddenly as i was pulling onto the M25. Drove to work today, and it is way down on power, stopped at my local citroen dealer to check availability of the hoses both of which they say are on back order !!
Reply
#5
as suspected duamo hdi, removed boost pipe and silicone top pipe has a small hole in it, nice one, will patch it up till citroen send me a new one
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Berlingo won't start 2009...
Last Post:Chri5
Today 12:22 AM
» Replies: 7
» Views: 167
Insurance!
Last Post:fcamp
Yesterday 10:52 PM
» Replies: 6
» Views: 822
citroen berlingo desire 1...
Last Post:sks01773
Yesterday 10:47 PM
» Replies: 2
» Views: 34
1.6 16v petrol cambelt
Last Post:sks01773
Yesterday 10:40 PM
» Replies: 0
» Views: 14
B9 DPF Tank Top-Up
Last Post:Lighty
Yesterday 10:06 PM
» Replies: 5
» Views: 112
Rear light Cluster
Last Post:Peter Guy
Yesterday 09:57 PM
» Replies: 2
» Views: 25
2012 enterprise berlingo ...
Last Post:CourierJim
Yesterday 09:03 PM
» Replies: 6
» Views: 118
Head gasket failure.
Last Post:Civvic
Yesterday 08:08 PM
» Replies: 13
» Views: 360
At last
Last Post:Gerald Bostock
Yesterday 08:06 PM
» Replies: 9
» Views: 327
Conversion from manual to...
Last Post:Civvic
Yesterday 07:58 PM
» Replies: 1
» Views: 88

Locations of visitors to this page