Thread Rating:
  • 9 Vote(s) - 3 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Temp gauge reads high all the time
#1
Berlingo 2.0 hdi van on an 02 plate, temp gauge stays on high, stop light on. Engine fan continually running, Checked not overheating and full coolant, replaced temp sensor in engine compartment, still not fixed.... Any ideas please
Reply
#2
Hi, the temp sensor (should be green with two wires) goes straight back to the engine ecu on the 48pin brown plug.
Do a shutdown procedure and disconnect the battery.
have a look at these connections and make sure they are clean / no corrosion.
Don't forget to do a correct start up procedure.

What happens if you leave the sensor disconnected? Confusedcratch:
Do you still get the same fault?

http://www.bba-reman.com/content.aspx?co...ot_process

Confusedalut:
2006 2.0hdi 600 with bench seat.  Cool
Reply
#3
(21-06-2012, 06:57 PM)Rustscrat Wrote:  Hi, the temp sensor (should be green with two wires) goes straight back to the engine ecu on the 48pin brown plug.
Do a shutdown procedure and disconnect the battery.
have a look at these connections and make sure they are clean / no corrosion.
Don't forget to do a correct start up procedure.

What happens if you leave the sensor disconnected? Confusedcratch:
Do you still get the same fault?

http://www.bba-reman.com/content.aspx?co...ot_process

Confusedalut:

Hi, thanks for the reply, if I leave the sensor disconnected, same fault. Sensor has been replaced with a new one. I took off the 48 pin plug and gave it a spray with wd40, it looks clean. Unsure of shutdown procedure, then followed your link Smile I will try that tomorrow (Cornwall, it's heaving down with rain!) when I get to work and a shelter. Smile
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Insurance!
Last Post:fcamp
Yesterday 10:52 PM
» Replies: 6
» Views: 815
citroen berlingo desire 1...
Last Post:sks01773
Yesterday 10:47 PM
» Replies: 2
» Views: 28
1.6 16v petrol cambelt
Last Post:sks01773
Yesterday 10:40 PM
» Replies: 0
» Views: 9
B9 DPF Tank Top-Up
Last Post:Lighty
Yesterday 10:06 PM
» Replies: 5
» Views: 112
Rear light Cluster
Last Post:Peter Guy
Yesterday 09:57 PM
» Replies: 2
» Views: 18
2012 enterprise berlingo ...
Last Post:CourierJim
Yesterday 09:03 PM
» Replies: 6
» Views: 112
Head gasket failure.
Last Post:Civvic
Yesterday 08:08 PM
» Replies: 13
» Views: 354
At last
Last Post:Gerald Bostock
Yesterday 08:06 PM
» Replies: 9
» Views: 321
Conversion from manual to...
Last Post:Civvic
Yesterday 07:58 PM
» Replies: 1
» Views: 86
Rear seats
Last Post:Kevin Crisp
Yesterday 05:17 PM
» Replies: 0
» Views: 41

Locations of visitors to this page