Thread Rating:
  • 12 Vote(s) - 3.5 Average
  • 1
  • 2
  • 3
  • 4
  • 5
M59 Berlingo 2.0Hdi Flywheel
#1
One of the "advisories" from the garage after a recent service was "Dual Mass Flywheel noisy at start-up".
A bit of searching here suggests the Berlingo doesn't have a DMF. Can anyone confirm this definitively? Are they, in other words, talking bollocks?
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
2004 Berlingo Multispace Forte 2.0HDi in red.
Reply
#2
Cant say 110% but I think they're talking bollocks. I'll check definatively tomorrow if I get time.If it was a dmf and on its way out i'm fairly sure it wouldn't only be noisy on start up. Normally they clatter all the time like you've suddenly got another diesel under the bonnet.

Sent from 2 bean tins and a piece of string!
1.9d Mk2 (M59/BE4/5) with battle scars from a conservatory attack. Previously owned a 1.4i Mk2 Forte.Confusedalut:
Reply
#3
DMF wasn't fitted to the M59 2.0.

I'd use a different garage next time
Reply
#4
Thanks, I shall certainly be looking elsewhere in future.
Checkatrade ratings appear to be no guide to competence alas :-(
~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~
2004 Berlingo Multispace Forte 2.0HDi in red.
Reply
#5
Unfortunately, unless you get a recommend from someone you trust, it is pot luck.

If you find a good one, then hang on to them and don't let go !!
Reply
#6
Hmmm.....if that's the case then why are there so many of them advertised here?

http://www.ebay.co.uk/sch/i.html?_nkw=ci...s+flywheel

Looks like the 1.6HDi 2005 on has them.

http://www.ebay.co.uk/itm/CITROEN-BERLIN...404wt_1161

Not listed for the 2.0l HDi though.

AARRRRGGGGHHHH....It means I got one :eek::eek::censored:
[fon‌t=Tahoma, Calibri, Verdana, Geneva, sans-serif]The Older I get the Better I Was!  Cool [/font]
Reply
#7
Worst case scenario, I believe that there are complete kits available vis. Flywheel and Complete Clutch assembly to do away with and replace the blessed dual-mass flywheel....
Berlingo Multispace 2.0HDI '54 reg Mediterranean Blue
Reply
#8
If it does have a DMF I would be wary of replacing it with a single solid flywheel. I know DMF's are a PITA but replacing them with singles often results in pain.
I know of VW's and Fords that have been converted from DMF's and they're a rougher ride.
Just bear in mind that when / if you do change it you'll probably never have to again! :brickwall:
1.9d Mk2 (M59/BE4/5) with battle scars from a conservatory attack. Previously owned a 1.4i Mk2 Forte.Confusedalut:
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Rear Wiper Motor
Last Post:madwelshman
Yesterday 10:42 PM
» Replies: 3
» Views: 111
Heater control unit/resis...
Last Post:mreid63
Yesterday 10:34 PM
» Replies: 5
» Views: 333
Loud beeping from radio u...
Last Post:Tonyash
Yesterday 10:13 PM
» Replies: 0
» Views: 16
Facial light replacement
Last Post:Mike
Yesterday 09:23 PM
» Replies: 11
» Views: 287
Reverse light switch prob...
Last Post:willpisme
Yesterday 08:09 PM
» Replies: 7
» Views: 157
increase in a ratchet-typ...
Last Post:saskak
Yesterday 07:47 PM
» Replies: 5
» Views: 89
Rear hub nut torque setti...
Last Post:geoff
Yesterday 07:31 PM
» Replies: 4
» Views: 83
Heyup
Last Post:polar
Yesterday 07:18 PM
» Replies: 9
» Views: 367
New owner
Last Post:SheilaAnn
Yesterday 04:33 PM
» Replies: 12
» Views: 582
Repair a manual winder wi...
Last Post:Col
Yesterday 04:26 PM
» Replies: 3
» Views: 85

Locations of visitors to this page