Thread Rating:
  • 7 Vote(s) - 3.71 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Floppy Rear Sliding Door Handles
#1
I know this has been covered at some length in the forum, but I'm a little unclear about the pin replacement. Rolleyes

First of all, I am a complete DIY numpty, but I'm trying to change that ... fed up paying for something I should know how to do myself. With your help, who knows, I may even become a 'proper' man. :lol:

So, using the brute strength, just rip it off method I have removed the door card, trim and torx screws to reveal the rather complicated looking lock/operating assembly.

According to the 'Paynes' manual :whistle: I can see the two rods I need to unclip (marking first of course) and the two torx bolts holding the handle in place.

I assume once I have undone them the handle comes off?

The next bit is really unclear to me .... can anyone describe to me in plain (or even simpler) English what happens next? I think I just need to pull the knackered pin out and replace it with the new one. Lets hope it's that simple. Cool

I tell you what, if you help me out, I'll do a photo tutorial for the forum.
[Image: 108137.png]


Do not write below this line. Office use only.

Reply
#2
Bumped for the evening shift. Wink
[Image: 108137.png]


Do not write below this line. Office use only.

Reply
#3
(10-10-2012, 06:24 PM)thurrockdave Wrote:  Bumped for the evening shift. Wink

Sorry cannot be a lot of use about this but I am sure that there is a thread on here about this with some pictures of the 'pin'
--------------------------------------------------------------

2012 Iron Grey XTR 110 with lots of bits and bobs.
Reply
#4
(10-10-2012, 06:24 PM)thurrockdave Wrote:  Bumped for the evening shift. Wink

I found the thread but no photos Sad


http://www.berlingoforum.co.uk/showthread.php?tid=240
--------------------------------------------------------------

2012 Iron Grey XTR 110 with lots of bits and bobs.
[+] 1 user says Thank You to Trevor for this post
Reply
#5
A search reveals these:-

http://www.berlingoforum.co.uk/showthrea...=rear+door

http://www.berlingoforum.co.uk/showthrea...=rear+door

Might help
[+] 1 user says Thank You to Coco for this post
Reply
#6
Cheers guys!

I'd seen some of them before.

It's still the handle I can't visualise. Can't find a photo or diagram of it anywhere.

Looks like I might have to dive in, sink-or-swim and see how I get on.
[Image: 108137.png]


Do not write below this line. Office use only.

Reply
#7
What's the worst that could happen....................................................................................
Reply
#8
(11-10-2012, 05:25 PM)Coco Wrote:  What's the worst that could happen....................................................................................

The wife. Sad
[Image: 108137.png]


Do not write below this line. Office use only.

Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Rear hub nut torque setti...
Last Post:El Berlingo
Today 01:14 PM
» Replies: 3
» Views: 39
Poor cold startup 1.9
Last Post:jj9
Today 09:42 AM
» Replies: 35
» Views: 842
peugeot charger
Last Post:Jed Clampit
Yesterday 11:28 PM
» Replies: 5
» Views: 164
hello
Last Post:Jed Clampit
Yesterday 11:16 PM
» Replies: 2
» Views: 56
XTR heater control bulb r...
Last Post:VicG
Yesterday 10:57 PM
» Replies: 0
» Views: 40
Fuel consumption
Last Post:ron
Yesterday 09:41 PM
» Replies: 12
» Views: 307
Rear Wiper Motor
Last Post:minisandfords
Yesterday 08:48 PM
» Replies: 2
» Views: 96
Lower Ball Joint
Last Post:brodfather11
Yesterday 08:38 PM
» Replies: 2
» Views: 102
Bottom Ball joint
Last Post:Andyy
Yesterday 08:26 PM
» Replies: 6
» Views: 117
cutting out HDi 1.6 diese...
Last Post:Col
Yesterday 06:15 PM
» Replies: 18
» Views: 1479

Locations of visitors to this page