Thread Rating:
  • 4 Vote(s) - 3 Average
  • 1
  • 2
  • 3
  • 4
  • 5
M.O.T failure.... Emissions :(
#1
Went for the M.O.T this morning, raining hard, heat blowers on full... Lovely!! Smile

I arrived at the MOT station fairly confident It was going to go through without any problems but no..... not today. I'd bought the car as an mot failure and have been working over the last month getting it all sorted... to address the previous emissions issue I've tried an air filter change and a new exhaust as the old one was knackered, and in two pieces when I got the car.

Exhaust emissions carbon monoxide content after second fast idle excessive [7.3.D.4]

Fast Idle test

CO - 0.49% FAIL
HC - 31 ppm PASS
Lambda - 0.99 PASS

Second fast idle test

CO 0.49% FAIL
HC 31 ppm PASS
Lambda 0.99 PASS

Natural idle test

CO 0.42 PASS


These new readings are actually HIGHER than the previous readings taken on the MOT just before I took ownership of the car, on that one it was failing at 0.43 CO on the fast idle test and second fast idle test.

I'm pretty new to all this but I think It's looking like a new cat or lambda...

how do I test the lambda sensor?
Reply
#2
Try a good Italian tune up :thumbsup:
Somedays you're the pigeon, Somedays you're the statue.
Reply
#3
I would try cleaning the Lambda sensor first,as that costs nothing.
Copaslip the threads well on refitting.Confusedalut:
Strawberry flavoured windows  Dodgy
[+] 1 user says Thank You to ron for this post
Reply
#4
Try a fuel cleaner also..... remove the fuel filter and empty half the petrol out then refill with fuel cleaner and fit the filter back. Start the engine and leave to idle only for a few minutes. Put the remainder of he cleaner in the tank and go for a good fast drive.

Same applies for diesel drivers too. Works for me and advised to do so by " my " MOT man.
[+] 2 users say Thank You to geoff for this post
Reply
#5
(24-05-2013, 06:31 PM)ron Wrote:  I would try cleaning the Lambda sensor first,as that costs nothing.
Copaslip the threads well on refitting.Confusedalut:

Good Idea, I wasn't aware lambda sensors could be cleaned Smile how do I do it?

Cheers
Reply
#6
I'd guess he's going to say a good carby cleaner; one that loosens carbon, followed by a burn with the oxy torch.

I'm more negative about the longer term benefits of cleaning them; it may get you over the line for a test but is likely to relapse within the year.
Reply
#7
I'm booked in today for a new cat and fitted, I'd fit myself but I've done so much work on the vehicle lately that I really can't be bothered.

I'll put in a new lambda sensor too.

I just want it through now.
Reply
#8
Good luck.:thumbsup::thumbsup:
Strawberry flavoured windows  Dodgy
[+] 1 user says Thank You to ron for this post
Reply
#9
New cat on, sailed through!! Smile
[+] 2 users say Thank You to raindog for this post
Reply
#10
Well done that man.:woop::woop:
Strawberry flavoured windows  Dodgy
[+] 1 user says Thank You to ron for this post
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
DW8 engine tapping
Last Post:jj9
Today 01:14 AM
» Replies: 3
» Views: 91
Rear window heater repair
Last Post:Silverberlingo
Yesterday 11:38 PM
» Replies: 0
» Views: 19
New PureTech 110 S&S Flai...
Last Post:Jed Clampit
Yesterday 09:04 PM
» Replies: 3
» Views: 56
What website to pass time...
Last Post:Solent
Yesterday 08:32 PM
» Replies: 0
» Views: 30
Berlingo Parts
Last Post:Sb12
Yesterday 07:56 PM
» Replies: 0
» Views: 32
Rear hub nut torque setti...
Last Post:jj9
Yesterday 07:55 PM
» Replies: 15
» Views: 260
temperatue dial
Last Post:Kokain
Yesterday 05:28 PM
» Replies: 3
» Views: 76
Trip Computer on Type A M...
Last Post:cancunia
Yesterday 03:50 PM
» Replies: 0
» Views: 25
Loud beeping from radio u...
Last Post:nicko
Yesterday 03:49 PM
» Replies: 3
» Views: 113
Ligts won't go off!
Last Post:Berlingos12
Yesterday 02:50 PM
» Replies: 10
» Views: 470

Locations of visitors to this page