Thread Rating:
  • 7 Vote(s) - 2.86 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Berlingo Fuel Gauge Showing Nearly Empty
#1
Hi,i have a 2007 berlingo 1.6 hdi 90 van.was driving it & fuel gauge began reading nearly empty & low fuel light was on so i filled up with diesel but gauge still reading nearly empty & light still on.it wont move no matter how much fuel goes in.cant find an access panel to get to sender unit.got under van & did find a wiring plug near tank 1 end had 2 wires & other end had 4 wires in.
id be grateful 4 any advice on fixing problem.Might be a while b4 i,m able to reply to any answers due to work commitments but Thanx in Advance
Reply
#2
Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:

   
2006 2.0hdi 600 with bench seat.  Cool
[+] 1 user says Thank You to Rustscrat for this post
Reply
#3
(15-08-2013, 04:37 PM)Rustscrat Wrote:  Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:
Hi thanx 4 reply & the diagram i,ll have another look under van tomo & c if i can locate those wires now..........Many Thanks....Big Grin
Reply
#4
(13-08-2013, 03:16 PM)bobb Wrote:  Hi,i have a 2007 berlingo 1.6 hdi 90 van.was driving it & fuel gauge began reading nearly empty & low fuel light was on so i filled up with diesel but gauge still reading nearly empty & light still on.it wont move no matter how much fuel goes in.cant find an access panel to get to sender unit.got under van & did find a wiring plug near tank 1 end had 2 wires & other end had 4 wires in.
id be grateful 4 any advice on fixing problem.Might be a while b4 i,m able to reply to any answers due to work commitments but Thanx in Advance
Problem Solved...float on sender unit must of stuck when i ran tank low...put £20 diesel in tank but reading still empty so i just put another £15 of diesel in & gauge went straight to correct reading of all fuel in tank,,,,,,,,,,,,,,,,
[+] 1 user says Thank You to bobb for this post
Reply
#5
(15-08-2013, 04:37 PM)Rustscrat Wrote:  Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:

Hows it going i have the same problem with my 03 1.9 berlingo was just wondering do you have to take the fuel tank of to get at the sender unit or is the an easier access to it
Reply
#6
(08-11-2013, 10:50 AM)Mossym Wrote:  
(15-08-2013, 04:37 PM)Rustscrat Wrote:  Here you are, Item 1211 is your sender. First connection should be a 5 pin plug with only pins 1 & 5 used. pin 1 is (433) is a green wire which changes to a red one after the 4 pin connector. Pin 5 (4315) is green/yellow which stays the same through the 4 pin.
If this doesn't match yours let me know. :thumbsup:

Hows it going i have the same problem with my 03 1.9 berlingo was just wondering do you have to take the fuel tank of to get at the sender unit or is the an easier access to it

Hi thanks for reply,my sender had stuck when i let diesel run low,in the end i filled tank halfway up & took it on a bumpy road & the sender unit freed itself.Might be worth a try before removing sender unit.im not sure if you have to remove tank to get to sender but it does look that way.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
increase in a ratchet-typ...
Last Post:saskak
Today 05:31 PM
» Replies: 3
» Views: 50
New owner
Last Post:SheilaAnn
Today 04:33 PM
» Replies: 12
» Views: 558
Repair a manual winder wi...
Last Post:Col
Today 04:26 PM
» Replies: 3
» Views: 76
2-Button Key Upgrade
Last Post:Mojow Royle
Today 02:52 PM
» Replies: 1
» Views: 83
Heyup
Last Post:Mojow Royle
Today 02:49 PM
» Replies: 8
» Views: 354
Poor cold startup 1.9
Last Post:Top drive
Today 02:46 PM
» Replies: 36
» Views: 872
Rear hub nut torque setti...
Last Post:El Berlingo
Today 01:14 PM
» Replies: 3
» Views: 67
peugeot charger
Last Post:Jed Clampit
Yesterday 11:28 PM
» Replies: 5
» Views: 177
hello
Last Post:Jed Clampit
Yesterday 11:16 PM
» Replies: 2
» Views: 59
XTR heater control bulb r...
Last Post:VicG
Yesterday 10:57 PM
» Replies: 0
» Views: 43

Locations of visitors to this page