Thread Rating:
  • 5 Vote(s) - 3.2 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Berlingo 1.9d not starting in morning
#1
So my Berlingo won't start in the morning. I've had heater plugs replaced, I've primed fuel pump until it's firm, no air bubbles and still no start. I have to get a push start every morning to get it going but once it's going, it will restart generally fine after that for the day. Managed to get it started with easy start spray too.

Any ideas?
Reply
#2
Are the glow plugs coming on?
[+] 1 user says Thank You to addo for this post
Reply
#3
(01-09-2013, 08:37 AM)addo Wrote:  Are the glow plugs coming on?

I don't know, but the mechanic doesnt seem to think they are the problem.
Reply
#4
You need fuel, air, compression - and a little warmth to kick it off. I'd first check the glowplug relay, then the pump timing. Not sure what cold start mechanism it has on the pump, but someone else will have an idea on checking this detail.
[+] 1 user says Thank You to addo for this post
Reply
#5
My cold start mechanism wasn't working when I bought the car. Someone had tweaked it so it was permanently on fast idle. When I reset it to normal idle it wouldn't start easily. Or rather it would start then it would die until the engine had warmed up a bit.
I'm fairly sure someone on here told me the part no. then I bought one but can't remember if it was from the dealers or from ebay. You'll need a 32mm spanner if you do decide it needs changing.
Malc

Stupid computer!
Security system should not fail safe!
Security system should fail dangerous!
[+] 1 user says Thank You to crickleymal for this post
Reply
#6
A few days i has one Berlingo 1.9d whit that problem. The glowplug relay burn and don´t work. Put a wire in the positive of the batery and on the glowplug and turn on the van... If it works is the relay...

sorry for my language.
[+] 2 users say Thank You to andre 21 for this post
Reply
#7
(01-09-2013, 07:54 PM)andre 21 Wrote:  A few days i has one Berlingo 1.9d whit that problem. The glowplug relay burn and don´t work. Put a wire in the positive of the batery and on the glowplug and turn on the van... If it works is the relay...

sorry for my language.

Thanks for that. Where is the glowplug relay on a berlingo?
Reply
#8
It's on the passenger wing
Somedays you're the pigeon, Somedays you're the statue.
Reply
#9
Yes, in the UK, is in the passeger wing, on side of the headlamp. It´s green. And cost 58€ on the Citroën here...
Reply
#10
It will be the valve clearances, the valves recede into the seats with mileage, and then you loose compression as they begin to not close properly. Usually happens at @120/140 K miles.
I have had to do them twice on my C15 van 267K miles nowSmile
This is assuming glow plugs working, and no air in fuel, which you seem to have done already.
[+] 1 user says Thank You to Lighty for this post
Reply


Forum Jump:


Users browsing this thread: 2 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
increase in a ratchet-typ...
Last Post:saskak
Today 12:36 AM
» Replies: 7
» Views: 119
DW8 engine tapping
Last Post:Hector Scorn
Today 12:30 AM
» Replies: 0
» Views: 11
Rear Wiper Motor
Last Post:madwelshman
Yesterday 10:42 PM
» Replies: 3
» Views: 114
Heater control unit/resis...
Last Post:mreid63
Yesterday 10:34 PM
» Replies: 5
» Views: 339
Loud beeping from radio u...
Last Post:Tonyash
Yesterday 10:13 PM
» Replies: 0
» Views: 23
Facial light replacement
Last Post:Mike
Yesterday 09:23 PM
» Replies: 11
» Views: 289
Reverse light switch prob...
Last Post:willpisme
Yesterday 08:09 PM
» Replies: 7
» Views: 160
Rear hub nut torque setti...
Last Post:geoff
Yesterday 07:31 PM
» Replies: 4
» Views: 96
Heyup
Last Post:polar
Yesterday 07:18 PM
» Replies: 9
» Views: 374
New owner
Last Post:SheilaAnn
Yesterday 04:33 PM
» Replies: 12
» Views: 586

Locations of visitors to this page