Thread Rating:
  • 6 Vote(s) - 3 Average
  • 1
  • 2
  • 3
  • 4
  • 5
[Engine] Fuel System fault - fuel filter
#1
We have four new 2012 Berlingo Vans 1.6 HDi. Two of them have been towed to the garage this month after the engine management light came on and the engine was in limp mode. The garage said this was a blocked fuel filter due to dirty fuel and drained all the fuel out and fitted a new filter.. However, both are new less that 20k miles, filled up at different service stations. On the second van we asked for the filter back, we took the fuel filter apart and found it was not a forced fuel filter but a full flow filter - ie the fuel washes past the filter not through it so it cannot block. Is this a problem any other members have had - we feel there must be another problem.
Reply
#2
Were there any fault codes registered??
2010 Berlingo Multispace HDi 110 with FAP. Persamos green.

[Image: ab197646.gif]
Reply
#3
(01-09-2013, 03:51 PM)3rensho Wrote:  Were there any fault codes registered??

Both vans

P0093 P 0087 and P2291
Reply
#4
Well, these codes all point to low fuel pressure. If the fuel filter is bypassed as you said above then I'd suspect the rail fuel pump. Was the output pressure checked?
2010 Berlingo Multispace HDi 110 with FAP. Persamos green.

[Image: ab197646.gif]
Reply
#5
(01-09-2013, 04:34 PM)3rensho Wrote:  Well, these codes all point to low fuel pressure. If the fuel filter is bypassed as you said above then I'd suspect the rail fuel pump. Was the output pressure checked?

Hello, thank you, the fuel filter was still in position - however the point I made about the fuel filter is that it has a hole for the inlet and an outlet and the fuel can simply pass through it without needing to go through the filter very poor design. That aside I am concerned that I have two vans with the same fault which seems odd to me, has anyone else had this problem ?
Reply
#6
Hello, the point I was making is that the problem might lie past the filter (see fault code reasons). The filter is not on the common rail high pressure side. The high pressure pump could be at fault. With today's production schedules it is possible a batch of defective pumps got through.
2010 Berlingo Multispace HDi 110 with FAP. Persamos green.

[Image: ab197646.gif]
Reply
#7
My 2007 1.6 hdi is putting up the same codes, plus P1351 which is a glow plug code. So I was wondering if there was any further developments on this??
Reply
#8
Well yes ... The problem was solved by draining all the fuel and renewing the filter. however when the filter was taken apart and checked I found it did not have the capability of filtering the fuel due to poor design there was a hole straight through the centre of it !
I challenged Citroen and they refunded the cost of the filters and the labour.
So something is wrong in the fuel system somewhere and they did not quible about a refund
Reply
#9
(05-10-2013, 10:31 PM)EMANUEL Wrote:  Well yes ... The problem was solved by draining all the fuel and renewing the filter. however when the filter was taken apart and checked I found it did not have the capability of filtering the fuel due to poor design there was a hole straight through the centre of it !
I challenged Citroen and they refunded the cost of the filters and the labour.
So something is wrong in the fuel system somewhere and they did not quible about a refund

hi there. so what filter do you have in them now? can you also describe the hole through the centre as every berlingo filter i have seen has a hole through center, top to bottom.
as far as i could see in mine, when i looked at it this morning, fuel goes through the middle and out through the walls of the filter?

what filters do you have now?

p.s. congrats on getting money back from a dealer! in my experience they keep changing parts until problem fixed and whe it goes wrong a few days later, they don't give you anything except offering to change even more parts!

thanks.
Reply
#10
I guess your vans have the metal canister fuel filters, cannot comment on the fuels ability to bypass, as I never looked that hard.
Our your staff feeling the vans with iffy fuel (just a thought ). These filters are due replacement on 2nd service as far as I know , but 20k is a little early for blockage.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
increase in a ratchet-typ...
Last Post:saskak
Today 12:36 AM
» Replies: 7
» Views: 119
DW8 engine tapping
Last Post:Hector Scorn
Today 12:30 AM
» Replies: 0
» Views: 11
Rear Wiper Motor
Last Post:madwelshman
Yesterday 10:42 PM
» Replies: 3
» Views: 114
Heater control unit/resis...
Last Post:mreid63
Yesterday 10:34 PM
» Replies: 5
» Views: 339
Loud beeping from radio u...
Last Post:Tonyash
Yesterday 10:13 PM
» Replies: 0
» Views: 23
Facial light replacement
Last Post:Mike
Yesterday 09:23 PM
» Replies: 11
» Views: 289
Reverse light switch prob...
Last Post:willpisme
Yesterday 08:09 PM
» Replies: 7
» Views: 160
Rear hub nut torque setti...
Last Post:geoff
Yesterday 07:31 PM
» Replies: 4
» Views: 96
Heyup
Last Post:polar
Yesterday 07:18 PM
» Replies: 9
» Views: 374
New owner
Last Post:SheilaAnn
Yesterday 04:33 PM
» Replies: 12
» Views: 586

Locations of visitors to this page