Thread Rating:
  • 2 Vote(s) - 4 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Poor starting hdi
#1
Can anyone help me with by 2002 Hdi. Over the last two winters the car has not started well on cold days [/size][/font]and appears lumpy at tickover until it has run for a short while. All glowplugs are ok and the control box and temperature sensor have been replaced.
These made no difference so I rigged up a manual switch to activate the glow plugs, sadly it did not work.
I recall seeing a couple of posts that say a new starter motor is the cure ,is this true and has anyone else had similar problem and come up with a solution?
Thanks
Reply
#2
A new starter motor will do nothing for a 'lumpy' tick over.
I would be looking at the condition of the battery. If its being hammered during start up then the voltage will drop until
the alternator has put back enough charge to restore the voltage at the battery terminals to around 14.5v.
If the battery tests OK then look at the battery lead connectors and earth leads. What voltage do you have at the battery terminals
directly after starting from cold with the engine running?
[fon‌t=Tahoma, Calibri, Verdana, Geneva, sans-serif]The Older I get the Better I Was!  Cool [/font]
Reply
#3
Battery is new mate. I forgot to mention that she takes a fair bit of cranking and when it does start it seems as if it is not running on all four.I also get a good cloud of smoke.
Reply
#4
OK. I'd still be checking the battery voltage with a meter at the battery terminals
looking for at least 14 volts. If it's any less than you can suspect a poor connection somewhere.
Have you had a diagnostic check to see if there are any fault codes stored. If there are codes they will
greatly help in isolating any problem.
[fon‌t=Tahoma, Calibri, Verdana, Geneva, sans-serif]The Older I get the Better I Was!  Cool [/font]
Reply
#5
Does it run OK after about ten mins. or so ? Once its het up a little?
Reply
#6
(16-09-2013, 07:13 PM)brodfather11 Wrote:  Does it run OK after about ten mins. or so ? Once its het up a little?

It runs quite well after I let it tickover and clear for about 30 seconds or so.It just does not start as well as it used to.

(16-09-2013, 07:10 PM)OlJeffers Wrote:  OK. I'd still be checking the battery voltage with a meter at the battery terminals
looking for at least 14 volts. If it's any less than you can suspect a poor connection somewhere.
Have you had a diagnostic check to see if there are any fault codes stored. If there are codes they will
greatly help in isolating any problem.

No fault codes at all just seems to be cold/damp weather thing.
Checked the whole lot so no idea at all.
Just remember seeing a post where someone said a new starter can solve these symptoms.
Reply
#7
Mine was taking longer to start and running a bit lumpy for the first few miles but after I swapped the fuel filter (after running far too low on fuel I think) it now starts like it used to and runs far better.

The job was simple BTW. 30mins for that and the air filter
Reply
#8
I'd say the valve clearances need checking and probably resetting ( bet a pound they have closed up ).
Reply
#9
(29-03-2014, 11:56 PM)geoff Wrote:  I'd say the valve clearances need checking and probably resetting ( bet a pound they have closed up ).

Hydraulic Geoff,not like your old tank.Rolleyes:wave::whistle:
Strawberry flavoured windows  Dodgy
Reply
#10
I wish I had a business running a motor factors as I'd make a fortune just by selling starter motors, batteries and alternators as people seem to keep replacing these items when they have a starting problem.

Thank god for an internet Forum where people get the chance to not be ripped off !

(30-03-2014, 12:00 AM)ron Wrote:  
(29-03-2014, 11:56 PM)geoff Wrote:  I'd say the valve clearances need checking and probably resetting ( bet a pound they have closed up ).

Hydraulic Geoff,not like your old tank.Rolleyes:wave::whistle:

That'll teach me to read the post properly with my own glasses on and not to use my wife's glasses !!!!

Hi Ron how are you doing, regards to your good lady :wave:
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
lubricating door
Last Post:brajomobil
Today 08:05 AM
» Replies: 2
» Views: 73
Lexia clone that works wi...
Last Post:brajomobil
Today 08:02 AM
» Replies: 59
» Views: 1853
Heated wing mirrors
Last Post:3rensho
Today 04:30 AM
» Replies: 4
» Views: 113
1.6 16v petrol cambelt
Last Post:cancunia
Yesterday 11:59 PM
» Replies: 13
» Views: 289
Ncb help
Last Post:Jed Clampit
Yesterday 10:32 PM
» Replies: 5
» Views: 160
Saying Hello
Last Post:Jed Clampit
Yesterday 10:25 PM
» Replies: 1
» Views: 36
1.6 hdi 90bhp Turbo and i...
Last Post:Floydster
Yesterday 07:48 PM
» Replies: 3
» Views: 143
2025 Diesel Ban
Last Post:Tree
Yesterday 06:17 PM
» Replies: 15
» Views: 367
Hello
Last Post:Johny555
Yesterday 06:04 PM
» Replies: 1
» Views: 27
Roof noise
Last Post:Veitcast
Yesterday 05:48 PM
» Replies: 0
» Views: 46

Locations of visitors to this page