Thread Rating:
  • 5 Vote(s) - 2 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Identify engine and gearbox
#1
Hi all. How do I identify which engine and gearbox I have?

Jan 2003 ( 52 reg ) 1.9 Diesel Van.

I am about to commence an epic 'rebuild'. Replacement gearbox, clutch, thrust bearing and pressure plate, cambelt, water pump, alternator/ps pump belt and an oil and filter change.

Might need a tailpiece to the exhaust and brake pads too. Depending on the engine Id I may need a crankshaft pulley I suspect as something down there is making one hell of a racket!

Anything else i should consider while I'm at it?

:eek:
Reply
#2
Replace the cambelt idler pulleys as well.As far as identification goes,if the eng/trans is all original,reg or V.I.N. should be enough for obtaining spares.As a tip,try GSF for parts,I've found them good.:thumbsup:
Strawberry flavoured windows  Dodgy
[+] 2 users say Thank You to ron for this post
Reply
#3
Thanks for that but I'm looking for a recon or used gearbox so I need to know what I'm looking for so a part number would be great.

Ordered a workshop manual on disk so hopefully that will be helpful.

Added idler pulleys to the list!
Reply
#4
    Look for the gearbox ID code, it's etched usually on the front or top of the box, there is a short code (which you want) followed by a unit serial. In the example shown the ID is 20CD74.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Reverse light switch prob...
Last Post:Col
Today 07:22 PM
» Replies: 12
» Views: 243
2004 Berlino Aerial
Last Post:Claydontoby92
Today 07:14 PM
» Replies: 0
» Views: 14
2005 2.0 HDI Siemens pump...
Last Post:Woodyrvf750
Today 07:05 PM
» Replies: 0
» Views: 15
Washers not working
Last Post:Silverberlingo
Today 06:54 PM
» Replies: 10
» Views: 268
Fuse is burning all the t...
Last Post:fernandoblas
Today 05:23 PM
» Replies: 12
» Views: 410
HELP! Smashed passenger w...
Last Post:Sootyfoot
Today 04:31 PM
» Replies: 2
» Views: 67
Diagnostic "gear" / Softw...
Last Post:cancunia
Today 04:19 PM
» Replies: 15
» Views: 612
Poor cold startup 1.9
Last Post:Top drive
Today 02:01 PM
» Replies: 38
» Views: 1031
Berlingo Parts
Last Post:malgpz900
Today 10:20 AM
» Replies: 1
» Views: 86
XTR heater control bulb r...
Last Post:Opensauce
Today 09:19 AM
» Replies: 1
» Views: 80

Locations of visitors to this page