Thread Rating:
  • 3 Vote(s) - 2.67 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Heater Fan / control
My 2008, 1.6 Turbo diesel Berlingo has a problem with its inside heater. The fan only works when I turn the control knob clockwise to number 4. Al help greatly appreciated
Probably the heater resistor unit, located in the air pipe work, near to the fan.
(17-12-2013, 06:27 AM)Lighty Wrote:  Probably the heater resistor unit, located in the air pipe work, near to the fan.

Thank you for response. Would you recommend repairing the unit or buying a replacement?
I would get a new one personally, as they can burn the wiring.
(17-12-2013, 07:43 PM)Lighty Wrote:  I would get a new one personally, as they can burn the wiring.

Any ideas as to where I can buy one in Ireland or online? Also what info about my van I need to furnish.
Best bet is to take your old one out so you know what it looks like and then go on ebay or europarts and compare like for like as there are a few different versions.
Something like this but check!!!!!!!!
Are we there yet????? No we fecking ain`t  gggggrrrrrrr
Ex 1.6hdi van now 3 seater 1.4 multispace
Thank you for all your help. I'll try that so over and out, (for now).
Make sure your fan rotates easily too. I had a similar problem with the fan in a Micra. It would keep burning out the fusible link on the resistor pack. I resoldered it several times. In the end I found the fan was stiff. Cleaning out the brushes and a drop of solvent followed by some WD40 made it spin much better and solved the problem.

Stupid computer!
Security system should not fail safe!
Security system should fail dangerous!
Thank you all for help. My resistor unit was above the fan and motor in the ducting. I removed the motor and fan and could see the resistor pack up in the housing where the fan is housed. There was no need to remove fan and motor as the resistor fits in a separate slot. Replacement part available from Citroen for €29. Simple job. Thanks.
[+] 1 user says Thank You to Peadar for this post

Forum Jump:

Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.



Search Forums

(Advanced Search)

Latest Threads
I'm hearing better or smt...
Last Post:andy-M
Today 07:18 PM
» Replies: 14
» Views: 372
Bump and Run - Am I right...
Last Post:doofer
Today 07:09 PM
» Replies: 19
» Views: 304
Eco activated but engine ...
Last Post:Satellitemark
Today 07:02 PM
» Replies: 30
» Views: 832
DPF Regeneration
Last Post:doofer
Today 06:39 PM
» Replies: 6
» Views: 196
Diagnostic "gear" / Softw...
Last Post:doofer
Today 06:33 PM
» Replies: 11
» Views: 275
2004 2.0HDi Cruise Contro...
Last Post:cancunia
Today 05:37 PM
» Replies: 2
» Views: 84
Still on the elusive 4x10...
Last Post:Carl Davis Hulin
Today 05:00 PM
» Replies: 4
» Views: 160
Newbie checking in
Last Post:Johny555
Today 01:57 PM
» Replies: 1
» Views: 34
M49 1.9 diesel misfire a...
Last Post:ricc
Today 01:14 PM
» Replies: 6
» Views: 159
replacing diesel fuel pip...
Last Post:Col
Today 10:30 AM
» Replies: 36
» Views: 2091

Locations of visitors to this page