Thread Rating:
  • 5 Vote(s) - 3.4 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Fuel pumb and BSI unit failure 2003 1.6 petrol
#1
Good evening all wonder if anyone can help. Wife and I were out for a drive this sunday and Berlingo Multispace coasted to a halt as if ran out of petrol.Petrol gauge showed 1/4 tank but topped it up with 5 litres just in case. However engine would only fire up for a few seconds then die.Thought it still sounded like a petrol problem so put in another 5 litres. No such luck same results. RAC man said it was a BSI fault with relay not switching on petrol pump and the associated fuse had failed which he replaced but still no joy. Then he injected easy start and engine ran for longer.Then he used his power unit and connected to fuse supply and it ran as long as he connected the supply.He could not work it out so towed us back home. Anyone know if this is this actually a BSI fault or a fuel pump fault before I start spending large amounts of cash to eliminate units that may be ok.
Reply
#2
Hi, first check its not the underbonnet fuse panel or "PSF".

This does fail at times but is far cheaper to replace (faster, too) than a BSI. If money is tight you could always add a little switch to power the pump.
[+] 1 user says Thank You to addo for this post
Reply
#3
if the van runs with the pump supplied its not the pump, sounds like the psf1 under the bonnet or a wiring fault as both these distribute the power to the pump, id get checked by an independent Peugeot specialist before shelling out on anything or at least do some basic checks if you know how to Wink
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Rear Wiper Motor
Last Post:madwelshman
Yesterday 10:42 PM
» Replies: 3
» Views: 111
Heater control unit/resis...
Last Post:mreid63
Yesterday 10:34 PM
» Replies: 5
» Views: 333
Loud beeping from radio u...
Last Post:Tonyash
Yesterday 10:13 PM
» Replies: 0
» Views: 16
Facial light replacement
Last Post:Mike
Yesterday 09:23 PM
» Replies: 11
» Views: 287
Reverse light switch prob...
Last Post:willpisme
Yesterday 08:09 PM
» Replies: 7
» Views: 157
increase in a ratchet-typ...
Last Post:saskak
Yesterday 07:47 PM
» Replies: 5
» Views: 89
Rear hub nut torque setti...
Last Post:geoff
Yesterday 07:31 PM
» Replies: 4
» Views: 83
Heyup
Last Post:polar
Yesterday 07:18 PM
» Replies: 9
» Views: 367
New owner
Last Post:SheilaAnn
Yesterday 04:33 PM
» Replies: 12
» Views: 582
Repair a manual winder wi...
Last Post:Col
Yesterday 04:26 PM
» Replies: 3
» Views: 86

Locations of visitors to this page