Thread Rating:
  • 4 Vote(s) - 2.25 Average
  • 1
  • 2
  • 3
  • 4
  • 5
berlingo diesel misfiring on partial throttle.
#1
ive got a misfire in my berlingo. Its fine when full throttle as on the motorwat 70mph, but when i back off due to traffic or a 50 mph zone and my throttle control is light, the van judders and misses. i have a faulty fuel sender and have run out of diesel twice recently. However, i have driven several hundred miles since this so an air lock is out of the equation. Any suggestions as to what it might be?

Thanks.
Reply
#2
I have exactly the same problem only mine now also happens 30 in 3rd 40 in 4th etc...

see -
http://www.berlingoforum.co.uk/showthread.php?tid=4525
Reply
#3
(22-01-2014, 03:21 PM)runningman Wrote:  I have exactly the same problem only mine now also happens 30 in 3rd 40 in 4th etc...

see -
http://www.berlingoforum.co.uk/showthread.php?tid=4525

Yes, mine is the same too. doesnt matter what gear it is in. its worse at around 1800-2000 RPM.
Reply
#4
I have same problem at 50 mph in 5th gear ! I have replaced egr valve , air mass metre , crank and camshaft sensors , temperature sender , throttle unit all with genuine parts and diesel and air filter and it still does it ! Not happy !
Reply
#5
(26-01-2014, 10:01 AM)royboy302 Wrote:  I have same problem at 50 mph in 5th gear ! I have replaced egr valve , air mass metre , crank and camshaft sensors , temperature sender , throttle unit all with genuine parts and diesel and air filter and it still does it ! Not happy !


hi new here

ive exactly the same problem

shuddering at low speeds eg 50 mph in 5th gear

so far heres all ive replaced

all the engine mounts " they where worn from the shuddering but they are not the cause "

airflow metre
driveshafts and bearings
the bottom engine mount was loose but again this was just caused by the shudder .
cheaked and cleaned the egr valve
cheaked tyres and wheel balance
cleaned the crankshart sensor
added diesel additives

none of these worked

its driving me nuts
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Running on chip oil
Last Post:polar
Today 04:07 AM
» Replies: 1
» Views: 12
Poor cold startup 1.9
Last Post:Top drive
Today 12:24 AM
» Replies: 40
» Views: 1081
2004 Berlino Aerial
Last Post:brodfather11
Yesterday 10:48 PM
» Replies: 1
» Views: 35
Washers not working
Last Post:Lighty
Yesterday 09:09 PM
» Replies: 11
» Views: 304
Reverse light switch prob...
Last Post:Col
Yesterday 07:22 PM
» Replies: 12
» Views: 263
2005 2.0 HDI Siemens pump...
Last Post:Woodyrvf750
Yesterday 07:05 PM
» Replies: 0
» Views: 32
Fuse is burning all the t...
Last Post:fernandoblas
Yesterday 05:23 PM
» Replies: 12
» Views: 417
HELP! Smashed passenger w...
Last Post:Sootyfoot
Yesterday 04:31 PM
» Replies: 2
» Views: 74
Diagnostic "gear" / Softw...
Last Post:cancunia
Yesterday 04:19 PM
» Replies: 15
» Views: 619
Berlingo Parts
Last Post:malgpz900
Yesterday 10:20 AM
» Replies: 1
» Views: 91

Locations of visitors to this page