Thread Rating:
  • 1 Vote(s) - 4 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Disconected rubber pipe?
#1
Hi,I have bought a Berlingo MK1 1.9D cheap/low millage but needs a bit of TLC...This is the first time working on one of these...behind the battery on the left hand side there is a small black plastic cilinder with two rubber pipes on top and electric wires connected to it on the side...One pipe is still connected but the smaller pipe has been taken off...I traced the pipe that is off and it goes to the front of the engine but is not connected and has been blocked in the end with a plastic bung...I have looked for this part in the Haynes manual but can not see it listed...could someone please tell me what this is and why it is disconnected...the engine runs ok.Thank you
Reply
#2
Sounds like it might be the hose to the EGR valve, many people block it to disable the EGR that is either faulty or clogged up with ****

http://www.berlingoforum.co.uk/showthrea...348&page=4

Have a look about half way down this page for a post by teddyc1, there is a diagram of the EGR system.
2005 Enterprise 600 1.9D - It did 85 once but started to smell funny.
Reply
#3
Yep is definitely the egr vacuum solenoid. It has probably been disconnected/ bunged due to being clogged at manifold and causing rough running. If you need help there are loads of egr threads on here Smile

Sent from my HTC Desire C using Tapatalk
Adam..2003..1.9D..LX..Silver Crew Cab Van.....
If at first you don't succeed, destroy all evidence that you tried.
Reply
#4
Thank you , Bob and Adam , now I know what its called I looked up EGR in Haynes and there is a picture and info for it...I also looked at other posts on here that helped a lot...for now I will blank it off...but I will take the rest of the parts off and clean them out..I will also look for a new EGR in case it does not pass emissions test. Kind regards, Stuart
Reply
#5
Should be fine unless smoky at idle or under load. It's worth a clean anyway...

Sent from my HTC Desire C using Tapatalk
Adam..2003..1.9D..LX..Silver Crew Cab Van.....
If at first you don't succeed, destroy all evidence that you tried.
Reply


Forum Jump:


Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.


  

Password
  





Search Forums

(Advanced Search)

Latest Threads
Haynes manuals - which on...
Last Post:jj9
Today 10:08 AM
» Replies: 1
» Views: 14
Fuel flap
Last Post:3rensho
Today 10:01 AM
» Replies: 1
» Views: 14
2.0 HDi fuel issues as pe...
Last Post:G.mk3
Today 10:01 AM
» Replies: 9
» Views: 158
Poor cold starting. Whats...
Last Post:geoff
Today 09:18 AM
» Replies: 10
» Views: 158
lubricating door
Last Post:ghost123uk
Today 09:13 AM
» Replies: 7
» Views: 157
Heyup
Last Post:Mojow Royle
Today 09:06 AM
» Replies: 5
» Views: 247
2012 enterprise berlingo ...
Last Post:Top drive
Today 06:57 AM
» Replies: 10
» Views: 269
Rear light Cluster
Last Post:Jed Clampit
Yesterday 09:52 PM
» Replies: 6
» Views: 142
1.6 16v petrol cambelt
Last Post:sks01773
Yesterday 07:27 PM
» Replies: 16
» Views: 388
Roof noise
Last Post:Opensauce
Yesterday 06:39 PM
» Replies: 5
» Views: 142

Locations of visitors to this page