Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Blanked egr problem
Hi guys, new to this forum. Have got myself a 2004. 2.0. Hdi berlingo multispace desire. Drove well for first week then kept dropping into limp mode,sometimes for a few minutes, sometimes days. Had diagnostic came up egr fault and was reset, one day later back into limp mode so got blanking plate and had fitted at local garage and all faults cleared. Car is still popping in and out of limp mode, how can this happen. Any advice please
2004 berlingo multispace desire 2.0 hdi
Perhaps it wasn't the egr at fault initially.
Somedays you're the pigeon, Somedays you're the statue.
Further information, have found car goes into limp when on overrun or ticking over, it then comes out if I let it idle for a minute or two then pull away. Maybe this will help diagnose.
2004 berlingo multispace desire 2.0 hdi
The Siemens ECU hates blanking plates or any fiddling with the EGR at all. Probably not related to EGR. Needs a Lexia on it as you've already guessed. I'd happily do it but I'm down near Reading and due to a head injury, been told I won't be driving for some time.

Sent from my GT-I9505 using Tapatalk
2004 Multispace Desire HDi - "Bertie"
As mentioned the Siemens system is touchy with EGR.
After about 6 good starts it should reset itself.
I've had mine disconnected for a few years and it only plays up after i reconnect it for the MOT, a few days later it sorts itself out and all is well again
Mine just went into limp - home mode when it was disconnected and there it stayed until it was reconnected!

Sent from my GT-I9505 using Tapatalk
2004 Multispace Desire HDi - "Bertie"
Thanks for replies to date, mikep hope you get well soon.
2004 berlingo multispace desire 2.0 hdi
Have now got fault code reader am getting a repetitive p1351 which I understand is to do with glow plug circuit and a p0402 which is egr excessive. Still have blanking plate fitted so how can egr be excessive???
2004 berlingo multispace desire 2.0 hdi
Googling egr excessive brings up a lot of info - too much for me to extrapolate and type out, have a search.

Forum Jump:

Users browsing this thread: 1 Guest(s)
Welcome, Guest
You have to register before you can post on our site.



Search Forums

(Advanced Search)

Latest Threads
Dead BSI unit?
Last Post:brajomobil
Today 06:26 AM
» Replies: 3
» Views: 38
2012 berlingo radio setti...
Last Post:NANO_Vigo
Today 02:19 AM
» Replies: 10
» Views: 212
Black Smoke
Last Post:Jed Clampit
Yesterday 10:07 PM
» Replies: 3
» Views: 90
Strange exhaust blowing n...
Last Post:dieselj
Yesterday 10:00 PM
» Replies: 1
» Views: 41
My Berlingo Camper build....
Last Post:Jed Clampit
Yesterday 09:58 PM
» Replies: 8
» Views: 358
DPF Regeneration
Last Post:Jed Clampit
Yesterday 09:46 PM
» Replies: 4
» Views: 75
New Battery
Last Post:Jed Clampit
Yesterday 09:35 PM
» Replies: 3
» Views: 68
Window mechanism replacem...
Last Post:Kez
Yesterday 09:01 PM
» Replies: 2
» Views: 65
Air Vent Directors Loose
Last Post:doofer
Yesterday 08:19 PM
» Replies: 2
» Views: 203
Roof bars for VTR?
Last Post:ffrenchie
Yesterday 08:01 PM
» Replies: 6
» Views: 132

Locations of visitors to this page